Batteries Suited For Electric Car Conversion

Battery selection is key for any electric car conversion, in order to get the most efficiency. You can’t use just ordinary starter batteries, like what’s in your gas powered car right now. They are not designed for long high current discharges. Deep cycle batteries are the type you will need to use,as they can put out high current for an extended amount of time. The most used battery for an electric car is the lead acid battery, which breaks down into three major types.

The Flooded or “wet” cell is by far the most available lead acid battery. If they are the type with removable caps, then you have to periodically check and refill the cells. All batteries will produce hydrogen and oxygen when recharging, and you will lose a certain amount of water during this process unless the battery is of the sealed type ( maintenance free) The benefits of using this type of battery is usually the cost, they are the least expensive. They are also less sensitive to overcharging as compared to the other types of cells. However they can also be prone to collecting deposits on the plates if they are left in a discharged state for extended periods. This is called sulphanation, due to the sulphate crystal deposits that can form on the plates. There are devices known as”desulphators” which as their name implies can eliminate the deposits and basically rejuvenate an old battery back to usable condition. The flooded battery must also be kept charged up. A deep discharge without a quick recharge will cause the battery to lose its capacity. Flooded cells will perform best if the discharge is kept to only about 50 saturation. Sometimes called “starved electrolyte” since the mat is not fully saturated, these batteries will not leak even if the case is broken. This is particularly good because of their non-hazardous status, the cost to ship them is lower. Also since there is no liquid electrolyte to freeze and expand, they are immune from being damaged due to freezing weather. Most all AGM batteries are 99 to 3% per month) so they can sit idle with no charging for extended periods, unlike typical flooded batteries. the only downside to this type of battery is the cost. They will typically cost 2-3 times more than your conventional flooded type.

Your choice of the electric car conversion whether it is DC or AC, is going to be the deciding factor in your battery choice. If you choose to do a DC conversion you will want to use the 6 volt battery to make up your battery pack, simply because they provide the most amps for the size and weight. If you go with an AC conversion, you will want to use the 12 volt battery, as you need the extra voltage to make up the higher voltage requirement of the
controller. Which ever voltage type you choose, the flooded lead acid is the best choice from a cost/power ratio. As battery technology continues to
progress however, you could soon see the day when AGM batteries becomes as cost effective as the traditional flooded lead acid battery.

Posted in Uncategorized | Comments Off

Parts For Your Electric Car: Buying Cheap And Right

Converting from gasoline to electric requires relevant parts and components. You would need these for a successful conversion. How well your car will function after the conversion will depend on the quality of parts and the expertise of the technician who did the conversion. For these reasons, it has become necessary that you devote a lot of time to finding the right parts so that you have a trouble free driving after you get your electric car.

The right parts will ensure that your car works as a functional unit and that you do not have misaligned components. You will be able to keep your car for long if you are able to fix the right parts from reputable manufacturers.

An electric car is supposed to bring a lot of savings to the motorist. He should therefore be in a position to buy components that will ensure that in the end the conversion has become profitable. Parts that are too expensive will result in a costly conversion; in which case the motive for the conversion would have been defeated.

You would have to examine each component carefully before you pick a choice. You may want to ensure that the electrical fittings and the motor especially are up to standard. Electric car wiring differs from that of the conventional car in the way the cables are run. Using inferior cables may lead to overheating and current flow problems as the electric car has more wiring and higher current demand than that of the regular car. The motor would also need to be the right type with the correct voltage and wattage to provide optimum performance.

Lastly, you must buy cheap to get an affordable conversion. Online shops are the best places to compare prices and features.

Posted in Uncategorized | Comments Off

Make Your Own Electric Car

It’s really not as hard as you think to make your own electric car. We used to think just like you… that it was beyond our skill level to make your own electric car, but after actually converting our car to electric we found that it’s really a lot easier than we initially thought.

To start off with you’ll need a good set of plans. This step is crucial as plans can make or break your project. We know from previous experience that good plans are an absolute must.

The second thing you’ll need are all the parts to build your electric car with. This includes the motor, 10 – 12 deep cycle batteries, nuts and bolts, and somebody to help you. A good helper makes things go twice as fast. You can find the motor on eBay. Don’t worry too much about the specifications, it won’t really affect your speed that much anyways. I’m sure you’re thinking “Wow, 10 deep cycle batteries is going to cost me at least $1000″. That’s true if you buy them new, but over the years we’ve found many different ways to reduce the costs of our projects. The benefit to you is that you should be able to find all of your deep cycle batteries for free.

Free batteries to make your own electric car with? That’s right, we stumbled over this little trick about six years ago while I was working on a golf course for the summer, but let’s not spoil the surprise.

Now that you have the motor and batteries you can begin to make your own electric car. You’ll need to hoist the motor out of the car (not as hard as it sounds, it’s only connected by a few bolts). After that you can mount the electric motor in and hook it up to the drive shaft. Then you can go and mount the batteries on top of the motor. The batteries get hooked up to a potentiometer (simply a thing which controls how much electricity you send to the motor) so you can control how fast the car goes. There are a couple more steps, but they’re discussed on the website.

The best part about my electric car? The fact that I pay about $0 PER MONTH to drive it (we live on renewable energy). If you’re still hooked up to the grid even then it will only cost you about $20 per month to drive your electric car. Now that’s what I call fuel savings.

Posted in Uncategorized | Comments Off

The New Generation Of Electric Car Batteries

Electric cars run on batteries anywhere from 12 to 24 of them underneath the hood. When it comes time for new batteries, they are actually readily available. The batteries used to run an electric car are similar to those used to power cell phones and even those little vehicles that kids like to drive around the yard. Getting new batteries for your electric car should not be a problem when the time comes.

The reality is that electric car batteries last for quite a long time, so getting new ones will not have to happen for quite a long time. When you do have to get new batteries for your electric car, you can expect to pay around $2,000 to $5,000 for them depending on the make and model of your electric car.

Some batteries have memories in them and if you do not run them out before charging them, they lose some of their potency. Be completely aware of how much electricity you have left before you go to plug in for a recharge. You may find yourself having to buy new batteries for your electric car before you really want to.

The electric car industry is always coming up with new battery technology that can help power your vehicle longer and charge faster. It is only a matter of time before that technology will allow you to drive your car further before a charge. That is good news for people who are electric car enthusiasts. Right now, the general range is around one hundred miles per charge. It is entirely possible that by the year 2010, you will be able to drive an electric car over 200 miles on new batteries.

When the time does come to get new batteries for your electric car, you can rest assured that you will be able to recycle almost the entire battery. Electric car batteries are 95 percent recyclable. You have an electric car, most likely, because you want to do something good for the environment and give yourself some relief from the ridiculous price of gasoline. Well, being able to recycle an electric car battery before you buy new ones, you can have peace of mind and a new source of power.

Choose the best type of battery for your need when you are buying new batteries for your electric car. Get the best battery you can find for the money and rest assured that you are doing your part both for the environment as well as for yourself.

Posted in Uncategorized | Comments Off

Learn Pros And Cons About The All Electric Car

While electric cars are a relatively new automotive technology, they are although fast becoming popular worldwide. A conventional car is very different from an electric car. An all electric car is a type of vehicle that uses a mixture of various technologies such as internal combustion engines, gasoline, electric motors, and batteries to run.

All Electric Cars

All electrical cars are set on batteries that provide electricity to an electric motor in the car, the engine turns the transmission, and the transmission spins the wheels. The attempt here is to increase mileage and reduce emissions as much as possible.

Structure

The structure of the electric car is simple, with the major components being: gasoline engine, motor, generator, fuel tank, battery and transmission. Many of these components are similar, and some even identical to those in conventional cars, but electric cars have different functions and are more convenient for you, your family, and the environment.

Advantages

There are many advantages that are accompanied in an electrical vehicle. Namely, you are saving air of pollutants that would otherwise be spewing into the environment. Electrical vehicles are 100% emission free, and are free of pollution by-products. They provide their power from batteries, solar, or hydrogen fuel cells.

Electric cars therefore are emission free, compact, lightweight, and they are three times as efficient as gas engines. They also have excellent ranges, and are safe to drive.

Electrical cars combine the best of both conventional and electric cars for a true winner. They bring more clean energy from the electric motor with the long-range power of gasoline engines, really giving you the best of both worlds.

Shortcomings

Just as there are advantages, there are some drawbacks to electrical cars. Electrical cars tend to require long recharge times. This means that you can not use a car while the battery is charging. Electric cars also tend to have expensive costs associated with them, should they every break down outside the warranty coverage. Although, the good news is that over the years the repair costs have significantly come down due to manufacturers better understanding the technology, and have become much more adept to building reliable parts.

To decide your next purchase, weigh the advantages and disadvantages in order to identify what is the best electric car for you.

Posted in Uncategorized | Comments Off

Know the Matters and Get the Best Benefits From Automotive Batteries

Automobiles need batteries to get electric energy and for this purpose, automotive batteries were invented. These batteries are rechargeable and small in size, so that they can be set up in automobiles very easily. Especially, it is regarded as an automotive battery. The work of an Starting, Lightning and Ignition is to supply energy to the starter motor for an automobile.

Six galvanic cells are used to make these batteries and they are usually lead acid type. At full charge, an automotive battery provides 12.6 volts. One single Starting, Lightning and Ignition is enough for a small vehicle. But heavy vehicles like highway trucks, tractors etc. that have diesel engines use more than one batteries.These batteries are recyclable, for this reason, they are environment friendly too. And through this process, every year a huge number of batteries are produced. There are usually four types of automotive batteries. They are described below shortly:

• Flooded Cell Type: These types of automotive batteries are inexpensive and working for long time period. But, they require a lot of maintenance and care. But, they can be leaked or spilled at any moment.

• Valve Regulated Lead Acid: They are the alternatives of Flooded Cell type batteries and more expensive than Flooded Cell Type Batteries. These batteries are also known as “sealed” batteries. You cannot repair these batteries and maintain them neither. Hydrometer cannot be used to measure the charge of these batteries and you cannot replenish the electrolyte too. These batteries are maintenance free and are usually used to stay safe from any kind of leakage.

• Shallow Cycle: To start an automobile engine, a large burst of power is needed. And for this purpose, Shallow Cycle batteries are really useful. They can produce a strong power when an engine starts. After that, they are charged by the engine driven charging system. They contain higher specific gravity electrolyte so that the internal resistance can be reduced. Many thin separated plates are used to make these batteries.

• Deep Cycle: These types of batteries are made to provide continuous power for a long period of time. Especially, the small vehicles such as small boats, recreational vehicles, golf cart etc. use these types of batteries. To store energy from wind turbine or photovoltaic array, they are used too.

To use your battery for a long period of time, you have to follow some certain rules. Car batteries that use lead antimony plates may need water regularly. Specialists recommend using distilled water in a particular level. But, nowadays, most of the batteries do not require this watering. Always try to use a charging method that is safe. The most popular charging method is Trickle Charging. Do not over charge your or keep for a long time on charging. This may reduce your product lifetime. And even they can be dangerous.You should also be careful about storage and changing. And such, you can get the best service from these batteries.These processes are also useful for your own safety.

Eastman Industries Ltd. one of the leading auto battery manufacturers in India. Eastman offers a wide range of high quality automotive batteries, Vrla battery manufacturers, inverter and motorcycle batteries of JIS and DIN series.

Posted in Uncategorized | Comments Off

Choose the Right Automotive Equipment Distributors – It’s in Your Best Interest!

Do you want your shop to be the one that people turn to when they want the very best auto repair service? Then, you will need to have the very best equipment in the business! It is no secret that car models keep changing every single year and it makes great sense to ensure that you purchase equipments that are up to date.

It is no secret that the internet is filled with different Automotive Equipment Distributors, but only few of these distributors provide all the equipments that you will need at a really pocket friendly price. A good auto equipment distributor will provide world class equipments without charging you an arm or leg.

At a good equipment distributor, you can shop for tools and equipments that are specifically designed to make your auto repair service job a whole lot easier.

A reputable and reliable automotive equipment distributor such as “Automotive Equipment Distributors” provides customers with top quality automotive tools at awesome prices. Customers can even get great deals on great wheel alignment systems such as Hunter wheel alignment system.

The market of auto equipments for both personal and commercial use offers a whole lot of tools and equipments. If you want to add much more advanced tools to your auto workshop or you are just starting out your auto repair service, you will need to do some research on good auto equipment distributor online so that you do not end up purchasing equipments from a distributor with a questionable reputation in the industry. When you log on to the website of reliable and reputable automotive equipment distributors, you will not only get to learn a lot about the different kinds of auto repair equipments, you will also get to learn how to operate these machines safely as well.

Even for just routine checks, every auto shop needs auto equipments such as auto lifts, as a matter of fact, these auto lifts are fast becoming an important part of every auto shop.

You can find the following auto equipments (and more!) at a good equipment distributor:

* Tire changers
* Wheel balancers
* Alignment lifts
* Brake lathes
* Drive tools
* Power tools
* Compressed air systems
* Lighting
* Material handling
* Storage
* Furniture
* Engine hoists and stands etc

Nowadays, many individuals have their own vehicles and in a lot of cases, they choose to maintain their vehicles by themselves – the internet is filled with DIY learning materials! Such individuals can shop for auto equipments (for personal use) at an auto equipment distributor’s website and save tons of cash on their purchase.

The internet is indeed a really great place to shop for and find reliable and reputable automotive equipment distributors that will not only offer top quality auto repair and lift equipment, but also offer un-ignorable prices as well.

You can shop for all your auto repair shop equipment needs on the internet and have all your purchases delivered straight to your door step – in one piece!

Posted in Uncategorized | Comments Off

Auto Recycler for Your Damaged Car

Motor vehicles are the most recycled products because of the availability of auto recyclers. Auto recycling entails stripping a vehicle off its reusable parts and then crushing the remaining body. The reusable parts are sold and the crushed portion is recycled by a scrap processor.

Why recycle?

This is done to reduce wastage. Numerous cars are written off as scrap every year. It makes sense to remove the parts that can be used and reuse them. This is not only beneficial for the environment but also makes auto parts available at affordable prices to consumers. In fact, the car manufacturers bear recycling in mind while manufacturing cars. Hence, they provide parts that are long-lasting.

As is apparent, an auto recycler works on the principle of conserving the environment. The three Rs of environment conservation are Reduce, Reuse and Recycle.
Reduce:

This implies using fewer natural resources for conserving the environment. If auto parts are reused, then a lesser quantity needs to be manufactured. If manufacturing reduces then the natural resources used are reduced.

Reuse:

Reusing has a positive impact on the environment. Hence, auto parts that are removed and sold enable reducing the landfill.

Recycle:

Recycling auto parts is the basic function of a recycler. Recycling helps conserve the environment as it reduces landfill and depletion of the environment for creating new parts.

Benefits of auto recyclers:

Good for the earth:

• Recycling is beneficial for the earth because of the following reasons:
• Reduces dangerous toxins from being released into our ground and water.
• It prevents the use of valuable landfill.
• It helps preserve the natural resources as it reduces the need for manufacturing new parts.

Good for your wallet

Recycled parts are available at nearly half the price as the original. Hence you save a good amount by purchasing them.

Good for your vehicle

The recycled parts are original and genuine made as per the original manufacturer’s specifications. In fact, many sellers of recycled parts even provide a warranty for them.

Hence, we see that auto recyclers, recycle End-of-life vehicles and protect water, air, and soil from harmful material contained in them.

So, if you have an end of life car, why sit around with it? Anyway, damaged cars do not have a book value so establishing a price for it will be difficult. Sell it to an auto recycler and earn cash in exchange! You will be doing your bit for the environment as well!

Posted in Uncategorized | Comments Off

Economize the Maintenance of Your Car by Using Recycled Parts

Auto recycling is one of the most widespread recycling industries globally. Auto parts are recycled from end-of-life cars. Damaged and old cars have usually have no takers. Hence, instead of just abandoning them, it makes sense to recycle their parts.

How are cars recycled?

• Damaged cars are bought by auto wreckers or recyclers. They are taken to auto recyclers which are large, open spaces for such cars.
• Over here, the car is inspected to check whether it can be repaired and reused or it is a write-off.
• In most cases, the car cannot be reused. Hence, the next step is to recycle it.
• Recycling entails removal of usable parts and their sale. This is followed by disposal of the parts that cannot be reused.
• Most of the parts such as the car stereo, windshield, wipers, mirrors, headlights, taillights, etc. if not damaged are sold in the market.
• Parts such as battery are removed and used to manufacture new batteries.
• Tires are used to make pavement bases for new roads.
• Wheels are removed and sold as metal scrap.
• If the glass is damaged, it is recycled to make porcelain, jewelry, beads, tiles, etc.
• After removal of all the parts and the various oils and fluids. The next step is the disposal of those fluids in a manner so that they do not affect the environment.
• Finally, the metallic portion of the car is left. This is crushed so as to reduce its size and then it is sold to a shredder.
• Most parts of the car are intact and can be reused. Many auto recyclers get the damaged parts restored so that they can be sold.

Every car needs spare parts for maintenance at some stage or the other.

Buying recycled parts is better than buying the original because:

1. These parts are available at nearly half the price of the original.
2. Since they have been removed from original cars, they provide a good fit.
3. These parts are genuine.
4. Many sellers of used parts provide a warranty for their products.
5. Recycling car parts helps in conserving the environment. This is because it reduces the need to manufacture new parts; since most parts are reused, the landfill is reduced; The pollutants are disposed of. By using these parts, you can also contribute towards conservation.

Hence, we see that using recycled car parts is not only beneficial to us but also works for the bigger cause of saving the planet.

Whether you need to buy or sell used car parts, you can do it with the help of Parts Locator, a leading auto parts resource in Australia. To know more visit here.

Posted in Uncategorized | Comments Off

Benefits of Recycling a Car

When a car is wrecked or damaged, what do you do with it?

Your options are repairing it and reusing it. Many a time this is not possible. In such cases, you can sell your car to an auto-dismantler. An auto-dismantler recycles the car for repairing other cars, selling used parts, etc.

An auto-dismantler removes all the functional and non-functional parts from a car. It also removes various fluids. The metallic portion that remains is crushed into a small piece and shred into pieces.

Recycling of wrecked cars has become a lucrative business option because the number of users of recycled car parts has increased.

Reasons for users of recycled car parts increasing:

• They are nearly half the price when compared to new parts.
• Manufacturers of car parts make these parts so that they are durable. This ensures that these parts last even after the car reaches its end-of-life.
• Used car parts have a good fit as they have been detached from original vehicles.
• Used car parts market caters to a wide range of cars.
• For cars whose models have been discontinued, the only option to look for spare parts is used car market.
• Vintage cars can find their spares in the used car market.

Besides these benefits, an auto-dismantler benefits the environment also. Imagine if cars were not dismantled and reduced in size, how much of waste we would generate? Cars also contain various hazardous and non-hazardous fluids which can impact the environment adversely.

Let us see what service an auto-dismantler provides to the environment:

1. Recycling of parts:

Various parts are removed from the car. Those that are intact are sold ‘as is’ in the market. Those that can be repaired are restored and sold. Others that cannot be reused as functional parts are used in other applications. This reduces wastage and saves landfill. It also conserves our natural resources by reducing the need to manufacture new parts.

2. Recycling fluids:

A car contains many fluids such as coolant, brake fluid, transmission fluid, etc. Some of these fluids are recycled and can be reused. While some other fluids can be converted into fuels, etc. and reused. This is beneficial to the environment because some of these fluids contain harmful chemicals. If they are released into the earth, they can be detrimental to the health of animals, aquatic creatures, and humans. Some fluids are inflammable and so cannot be released into the environment.

3. Recycling Steel:

Steel is required for a variety of applications. But its manufacture uses up valuable natural resources. Therefore, recycling steel reduces the need to manufacture fresh steel positively impacting the environment.

Hence, we see that dismantling and recycling a car is beneficial in numerous ways.

Recycling auto parts has become very popular in recent times.Parts Locator is a source through which you can buy and sell used car parts. To know more visit here.

Posted in Uncategorized | Comments Off